CarterCopter
|
|
The CarterCopter is an advanced aircraft, a combined fixed wing aeroplane/autogyro currently under development by Carter Aviation Technologies.
The design has an gyroplane rotor mounted on top which is unpowered in flight, but it also has short fixed wings like a conventional aeroplane. Unlike a helicopter, the aircraft is entirely powered by a pusher propeller at the rear.
| Contents |
Takeoff
At takeoff the pilot angles the rotor flat and spins it to very high speed, then disconnects the engine and flips the angle of the main rotor blades so that the vehicle leaps into the air. The aircraft's main rotor then has enough momentum (due to heavy counterweights in the tips) that it can hover for a short time safely. The pilot then applies full power to the pusher and the vehicle starts to move forwards. As it does so, the air gets forced through the main rotor spinning it faster and giving more lift. The vehicle climbs into the air.
Cruising
Once the Cartercopter gets up to a forward speed of about 90 miles per hour (145 km/h), its stubby, lightweight wings provide most of the lift. The pilot then flattens the angle of the main rotor so it produces hardly any lift and this drastically reduces the drag. The Cartercopter then surges forwards in the air. Although the rotor is unused at high speed, the rotor is kept spinning as it keeps the rotor rigid, preventing excessive flapping.
Normally a helicopter or gyrocopter cannot go as fast as its rotor tip speed. This is because the retreating rotor blade would stop in the air, whilst the leading rotor blade would be travelling at twice the speed. The vehicle would 'fall over' due to lack of lift on one side and increased lift on the other side.
However, with the Cartercopter, the fixed wings are keeping the vehicle at the correct angle to the horizon and providing the lift. Since the rotor is unloaded, the aerodynamic forces on the rotor are very minor. This means that a Cartercopter can theoretically fly much faster than the tip speed of the rotor. The rotors would flap a little as they rotate to deal with the difference in lift between the two sides of the vehicle, but this is manageable.
The theoretical maximum speed of a Cartercopter is around 500 mph (800 km/h), which would be twice as fast as any helicopter has ever gone.
Achievements
At present, the prototype's engine is normally asprirated, and hence is limited to just 320 hp (240 kW) and the fastest Carter Aviation Technologies prototype has achieved is about 173 mph (270 km/h); which is still ~40% faster than a conventional autogyro.
A helicopter to go the same speed would need almost twice this power. Thus the Cartercopter seems to be about twice as efficient.
The maximum mu that has been achieved (mu is the ratio of rotor tip speed to airspeed) is 1.0 for a brief moment. (Cartercopter's pilot claimed that there was no great drama, and mu-1 was reached accidentally due to normal variations in rotor RPM and vehicle airspeed; the pilot described it as 'smooth' with no significant vibration.)
Potential
The bottom line is that the vehicle architecture potentially outperforms helicopters on every dimension except sustained hover, and should be much cheaper to buy and maintain. It also very nearly matches fixed wing aeroplanes- but with near-vertical takeoff and landing; and at only modestly higher cost to buy and maintain than a fixed wing aircraft.
External link
- Carter Aviation Technologies (http://www.cartercopters.com/)
See Also
|
Lists of Aircraft | Aircraft manufacturers | Aircraft engines | Aircraft engine manufacturers Airports | Airlines | Air forces | Aircraft weapons | Missiles | Timeline of aviation |